Show Posts

This section allows you to view all posts made by this member. Note that you can only see posts made in areas you currently have access to.


Messages - AylmerFreerider

Pages: 1 ... 4 5 [6]
76
Super 8 / Re: higher speed?
« on: May 15, 2017, 11:57:13 AM »
So I have purchased a Polini High Speed Variator and Technigas Silent Pro Exhaust.  mlsmith2924 I will let you know how this goes. 
Tseg I think the Variator should clear the rev issue when you disconnect the Purple wire.

I will also look at a bigger jet as well to match the exhaust. 

77
Super 8 / Re: higher speed?
« on: May 14, 2017, 03:37:17 AM »
Where I am from the restriction is speed.  Cannot go past 43.5 mph (converts to 70kph in Canada).

I did the wire first Tseg and then did the others.  I had done the boss first but it just bogged down and couldn't get and real speed without the extra fuel.  Had a garage install the jet and tune the carb.  Works well once it warms up now. 

I am looking at Sport/High Speed variator kit with the upgraded torque spring and heavier rollers.  I will look into the washer if this is the case I will up the jet to a 90 or 92 to make up for the extra air.  The only other thing I can think of at this point is actually changing the exhaust like Roytheroach mentioned.

So far 36 mph (58kph) a flat and 41.5mph (67) on a good downhill.

78
Super 8 / Re: Will cutting the CDI work on the new (Agility based) Super 8 models?
« on: May 12, 2017, 03:01:23 AM »
2015 Kymco Super 8 50R

All I did was remove the purple wire from the harness clip so I could clip in later when I got a proper CDI box.

No sawing involved.

I will take a picture tomorrow for you.

79
Super 8 / Re: higher speed?
« on: May 12, 2017, 02:59:20 AM »
TSEG I did not have to buy one as there was one in the seat compartment already with a larger jet in a ziploc bag from Kymco.
I had to install the boss myself it all.  Was surprised that the dealership had not done it already but they wanted to charge me for it.

Live and learn.

80
Super 8 / Re: higher speed?
« on: May 12, 2017, 12:17:00 AM »
I got the jet installed today.  Went from a 75 to an 82.  Better ability to hold the top end now and getting there a little faster. 
I did manage to hit 40mph downhill though after. 
So the list of what I have done:
1. Removed violet wire form harness to CDI - close 32-33 mph on flats
2. Change boss - got to 36 mph on downhill still 32-33 mph on flats but very boggy
3. Changed Jet to an 82 - solid 32-33 mph on flats got to 40mph downhill engine was peppy again.

The guy who did the jet for me told me I needed to change the exhaust and up the jet to a 92 to get the most out of it.

Was there a washer in the Intake Manifold?  The guy I was dealing with today didn't seem to think so.

81
Super 8 / Re: higher speed?
« on: May 11, 2017, 11:37:51 AM »
Following this.

Mine came with smooth boss and larger jet.  I replaced the boss and unhooked the violet wire and currently get 35 mph.  I found that once I replaced the boss though that I issues with accelerating  at the top end.  I am looking into getting the jet upgraded. 


82
Super 8 / Re: Will cutting the CDI work on the new (Agility based) Super 8 models?
« on: May 07, 2017, 01:35:54 PM »
I just bought one recently and I removed one of the purple wired and was able to get and extra 4 mph out of it. I now get 35mph.  I have to change out the boss next.  They supplied me with a boss and 82 jet.  So I am hoping to be around 42mph after changing the boss.  I do not want to touch the jet if I don't have to. 

Any luck with yours?

Pages: 1 ... 4 5 [6]